The Long Road Home

Still catching up on our travels. This post will bring us from Washington state all the way to our home base in Florida, with a couple changes of plans along the way.

We had a pretty quiet trip all the way from Washington state to Kentucky. Here are pictures of most every stop along the way.

IMG_1136

Night 1 – Aug. 18 – Spokane KOA, Spokane, WA

IMG_1141

Night 2 – Aug. 19 – Deer Lodge KOA, Deer Lodge, MT

IMG_1179

Night 3 – Aug. 20 – Hardin KOA, Hardin, MT

IMG_1189

Night 4 – Aug. 21 – Douglas KOA, Douglas, WY

On night 5, Aug. 22, we stayed in the Strasburg/East Denver KOA in Strasburg, Colorado. We failed to take a picture of that site, but you can insert whatever generic picture of an RV in a crowded campground with gravel sites and barely any vegetation.

Also, starting in Wyoming and continuing through Colorado and Kansas, we had a lot of windy travel. It wasn’t terrible (in other words, not too gusty), but it was fairly strong and will play a part later in our story.

IMG_1196

Night 6 – Aug. 23 – Wakeeney KOA, Wakeeney, Kansas

Note the water puddles in the above photo. We just missed the rain, chasing it across eastern Colorado and western Kansas.

IMG_1203

Night 7 – Aug. 24 – Country Gardens RV Park, Odessa, Missouri

We started catching up with the rain by our stop in Odessa, but it wasn’t too bad. It had moved on by the time we got there and it was a pretty dry night.

IMG_1208

Night 8 – Aug. 25 – Shawnee Forest Campground, Vienna, Illinois

We drove in pouring rain most all day on our way through Missouri. St. Louis was the worst – driving through downtown on I-70 through pouring rain. We were fortunate that it was Sunday and not too much traffic. Still, it made for a rather tiring driving day. We were glad that the rain stopped long enough for us to set up the trailer without it raining on us.

We rolled into Kentucky on Monday the 26th. We had a two-night stay booked in Lexington at the Kentucky Horse Park. There were a limited number of spaces available. We later found out that there were two different horse shows and a dog show all happening there both during and towards the end of the week.

IMG_1212

Our truck was due for an oil change so we called ahead to a dealer in Frankfort, Kentucky (about 25 miles away) and set up an appointment to have that done on Tuesday morning.

On Monday night (after another rainy day), we were getting ready to go out and see Malcolm’s brother playing with a band in Lexington after meeting him for dinner. Val pulled out a box with shoes that she was going to wear for the evening and found that the box had a little water on top of it. The box was in a cubby built into the closet in the front cap of our trailer.

We felt around and didn’t really feel much else in the way of water, so Malcolm decided there wasn’t much we could do at the moment but he would climb up on the roof in the morning and check it out. Fortunately, the rain was almost done (just spotty showers here and there). We headed on out to enjoy our evening.

IMG_1223

Big Band Music by Al DiMartino and his DOJO band.

IMG_1225

Visiting with Al DiMartino (left) and Malcolm’s brother David (middle – holding sax)

After we got back to the trailer, Val heard a funny noise in the bedroom and found that water was dripping from the ceiling wall outlet for the bedroom TV onto a hat she had sitting on the dresser. Malcolm pulled the outlet cover and some water dripped out and then quit. We left the outlet hanging out for the night. A trip up top was definitely needed the next morning.

The appointment for getting the oil changed was at 9:00 and we needed to leave about 8:30 to get there, so Malcolm climbed up on the roof before that to assess what our problem was. That’s when he found that our roof membrane had come loose and lifted while we were traveling – most likely helped along with the strong wind across the mid-western portion of our trip.

IMG_1231

The roof material pulled back from the center of the front cap, leaving a big gap for water to enter the front cap from above. That explained the water in the closet (directly below this seam).

IMG_1228

The air needed somewhere to escape, so it managed to pull the roof material out from under the front air conditioner and proceed to tear some flaps in the material (one flap was completely gone). This is where the water probably entered to travel in our ceiling to the electrical outlet. The plan now became a trip to an RV dealer for appropriate materials to repair the roof after the oil change.

IMG_1232

The forecast called for a chance of showers late in the afternoon (which, fortunately, did not happen), so time was of the essence to fix the pulled seam and the hole in the roof material. We stopped by an RV dealer and picked up a roll of Eternabond seam tape and a tube of self-leveling sealant. Malcolm patched up the hole in the roof material in front of the air conditioner with several strips of overlapped Eternabond tape and sealed the front cap seam with the self-leveling sealant.

We wanted to give the repair a good chance to set before we hit the road, so we managed to book two more days in a different spot at the Horse Park campground (there were literally about seven spots left).

Overnight on Tuesday, Malcolm realized that he had patched the roof and it shouldn’t leak if it rained. However, the roof material was still loose and stretched. If we hit the road with it fixed as it was, the roof material would probably lift and tear up what he had fixed already. Therefore, we needed some way to keep the roof material from billowing up on the way home (a two day trip).

The initial though was to wrap a couple ratchet straps around the front of the trailer and tighten them down. It wouldn’t be pretty, but it would get us home. As Malcolm looked on the internet for alternative ways to hold down the roof material for travel, he ran across someone in a forum post that mentioned that they had a dealer screw down some stiff material across their roof in several strips to at least get them home. The also mentioned that temporary fix worked for several more years before they sold their trailer.

Malcolm had an idea, so the next morning while we waited for check-out time to move our rig from one spot to another (giving whoever was there time to leave), we went back to the RV dealer to get some more Eternabond tape and self-leveling sealant. We also went to Lowe’s and picked up some metal pipe strap and some wood screws and washers.

Malcolm screwed down several strips across the roof and covered each one with Eternabond tape. It isn’t pretty and really wasn’t well sealed (yet) as Malcolm doubled over the “flaps” on the roof material and pinned it down with the strips, but it worked well enough to get us on down the road. Malcolm checked on it several times during the trip to make sure it wasn’t pulling up. We were also blessed with dry weather.

The following photos may make you shake your head and maybe there were better ways to do this, but hey, sometimes you gotta do what you can to get home.

IMG_1241

IMG_1242

To make up for our extra day in Kentucky (we cancelled the second day of our second spot – feeling comfortable enough with the repair to continue on) we planned only one stop on the way back to Florida – in Cordele, Georgia.

IMG_1243

Cordele KOA – Cordele, Georgia

We were hoping our roof patch would hold tight so we could just head on home and it did. But, we didn’t quite head on home. We made it to Cordele just fine. However, there was this matter of hurricane Dorian.

The evening we stopped in Cordele, Dorian was still heading west and strengthening into a category 4 hurricane. The track at that time was indicating it would cut straight through Florida as a category 4 or 5 hurricane, putting our home right in the center of the action. We made the decision that evening to head over to our son’s house in Panama City, Florida, and wait out the hurricane. There was still a possibility that the hurricane might even hit that area, so we were all on alert.

We parked next to David’s house to wait out the storm and see what was going to happen. We brought a bunch of stuff inside to sleep in the guest room, ironically enough on the couch bed that we had taken out of our trailer and donated to our son. We plugged the trailer into an outside outlet on David’s house to keep the refrigerator running.

IMG_1245

While we were at David’s, we celebrated Malcolm’s 60th birthday. Originally, we were going to be home for the birthday and had a couple nights booked at Disney’s Boardwalk Resort. We cancelled that reservation when we decided to avoid the area due to the hurricane.

We had a nice dinner out at a pizza place with David and one of his roommates and later had birthday cake at home.

IMG_1289

IMG_1301

While we were at David’s house, his next door neighbor offered to let us use his 50 amp electrical hookup that he had run for his own RV (but wasn’t ready to use himself just yet). We hooked up the last couple nights were were there and ran the air conditioner to keep the rig cool. We also stayed in the trailer the last night we were there as the couch bed was making Malcolm’s back hurt.

IMG_1287

With hurricane Dorian now heading up the east coast and Florida being out of danger, we said our goodbyes and headed on home on Thursday, September 5th.

IMG_1305

Forgot to mention that while we were at David’s house, Malcolm went out and bought another tube of sealant to seal the areas of the roof where the roof material was doubled over under the tape to keep water from finding its way in those areas. For now, the roof seems well sealed.

We contacted a company that comes out and rolls on new rubber roof sealant and got an estimate of $6,500 to fix it. We’re waiting to decide on how to go about having it repaired long term, but for now the temporary fix is holding fine and we don’t plan on going anywhere with the trailer the rest of the year (unless another hurricane heads this way).

 

2 thoughts on “The Long Road Home

Leave a Reply

Fill in your details below or click an icon to log in:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out /  Change )

Google photo

You are commenting using your Google account. Log Out /  Change )

Twitter picture

You are commenting using your Twitter account. Log Out /  Change )

Facebook photo

You are commenting using your Facebook account. Log Out /  Change )

Connecting to %s

This site uses Akismet to reduce spam. Learn how your comment data is processed.